Previous Article | Next Article 
Journal of Clinical Microbiology, January 2004, p. 453-457, Vol. 42, No. 1
0095-1137/04/$08.00+0 DOI: 10.1128/JCM.42.1.453-457.2004
Copyright © 2004, American Society for Microbiology. All Rights Reserved.
Development of a Single-Tube, Cell Lysis-Based, Genus-Specific PCR Method for Rapid Identification of Mycobacteria: Optimization of Cell Lysis, PCR Primers and Conditions, and Restriction Pattern Analysis
Izhar U. H. Khan and Jagjit S. Yadav*
Molecular Toxicology Division, Department of Environmental Health, University of Cincinnati Medical Center, Cincinnati, Ohio 45267-0056,
Received 5 May 2003/
Returned for modification 4 June 2003/
Accepted 29 September 2003

ABSTRACT
A single-tube PCR method was developed for efficient identification
of nontuberculous mycobacteria (NTM) and their environmental
isolates in about 3 h without conventional DNA isolation. The
following three steps were optimized or developed: (i) a simple,
6-min direct cell lysis protocol as a PCR prestep for generation
of DNA-template, (ii) an improved
Mycobacterium-specific PCR
amplification protocol with a broader species specificity using
newly designed primers targeting a 228-bp region of the 65-kDa
heat shock protein (
hsp) gene and optimal PCR amplification
conditions, and (iii) a genus-specific restriction analysis
of the PCR product for conclusive identification of the unknown
NTM isolates.

INTRODUCTION
Nontuberculous mycobacteria (NTM) are important causes of nosocomial
infections and occupational illnesses. These organisms are commonly
associated with natural ecosystems such as water supplies, aerosols,
food, and soil (
3,
4,
6,
7,
17). NTM that cause nosocomial infections
are frequently associated with hospital water supplies and washing
equipment. From an occupational health standpoint, NTM are considered
causal agents for hypersensitivity pneumonitis, asthma, and
bronchitis in machine workers exposed to metalworking fluids
(MWF) and their aerosols, which are used in metalworking industries
for cooling and lubrication (
8,
10,
12,
14,
18). A method for
early and reliable detection of mycobacteria from these environments
might help minimize these illnesses. The existing practice of
identification of mycobacteria from clinical and environmental
sources includes isolation using enrichment and selective agar
media, a method which often results in the collection of a large
number of putative isolates for subsequent screening and confirmation
by morphological, culture, and biochemical methods (
20). Molecular
methods such as PCR offer a significant alternative for rapid
screening and identification of these bacteria (
11). In practical
terms, the major limiting steps of the PCR approach for the
rapid screening are the extraction of amplifiable-quality genomic
DNA and the availability of genus-specific primers with broad
specificity for different species. Due to the complexity and
rigidity of the cell walls of these acid-fast bacteria, several
efforts have been reported for the rapid isolation of amplifiable
genomic DNA by using physical, chemical, or enzymatic strategies
or combinations thereof (
1,
5,
9,
13,
16,
22). However, these
cumbersome and/or time-consuming protocols failed to yield effective
cell lysis, thereby preventing their use in routine screening
and diagnosis of diverse environmental species of
Mycobacterium.
The two existing genus-specific PCR-protocols, one based on
a 16S rRNA gene (
15) and the other based on
Mycobacterium-specific
65-kDa heat shock protein (
hsp), are applied for identification
of mycobacteria (
16). The latter protocol has received wider
acceptance. However, this protocol fails to reliably amplify
the target
hsp sequence in some environmental species such as
Mycobacterium immunogenum, which is an important newly identified
NTM species widely associated with both clinical infections
and pseudo-outbreaks (
19) and with MWF implicated in hypersensitivity
pneumonitis (
18). Considering the above limitations, we designed
the present study to develop a simple and rapid cell lysis protocol
that would be usable as a prestep in PCR; we also sought to
develop an improved genus-specific
hsp gene-based PCR protocol
applicable to a broader range of
Mycobacterium species coupled
with a genus-specific restriction analysis of the amplicon for
more reliable detection and identification.

Bacterial strains and isolates.
Four reference strains of the genus
Mycobacterium,
M. chelonae (ATCC 35752),
M. smegmatis (ATCC 19420),
M. immunogenum (ATCC
700506), and
M. bovis BCG (ATCC 35741), originating from both
clinical and environmental sources, and a total of eight isolates
obtained from different types of used MWF originating from different
industrial plants at diverse geographical locations were used
for methods development and comparisons. In addition,
Bacillus sp. (B-22),
Escherichia coli (DH 5

), and
Pseudomonas fluorescens (ATCC 13525) were included as negative controls. For isolation
of mycobacteria, samples were plated on Middlebrook 7H10 agar
supplemented with oleic acid-albumin-dextrose-catalase enrichment
and Lowestein-Jensen agar slants and incubated at 37°C for
up to 10 days. Putative
Mycobacterium colonies selected based
on growth rate, colony morphology, and acid-fast staining reactions
were pursued further for confirmation by using the PCR method.

Cell lysis optimization.
Five different cell lysis reagents were prepared using various
concentrations of sodium dodecyl sulfate (SDS) and Triton X-100
(Sigma, St. Louis, Mo.) in Tris-EDTA buffer (pH 8.0) as presented
in Table
1. Initially, a six-step thermal regime involving different
heating-cooling temperatures and incubation times was used in
combination with each of the formulated lysis reagents using
the GeneAmp PCR system model 9700 (Applied Biosystems, Foster
City, Calif.). In order to develop a simpler thermal regime,
four other combinations involving shorter heating-cooling regimes
were examined, as shown in Table
2. By using a sterile autopipette
tip, we transferred an isolated mycobacterial colony to an amplification
tube (0.2 ml) containing 5 µl of a selected lysis reagent
and resuspended by gentle mixing. The contents were subjected
to lysis under the appropriate combinations of chemical lysis
reagents and thermal regimes listed in Tables
1 and
2 by using
the GeneAmp PCR system model 9700. The tube containing the crude
DNA-containing lysate was used directly for the subsequent PCR.

Genus-specific PCR.
We evaluated two distinct protocols for their applicability
to diverse mycobacterial species. The first was an existing
genus-specific PCR protocol based on the
hsp gene and involving
amplification of a 439-bp region using the recommended primer
pair (
16); the second was its modified version which uses newly
designed broad-spectrum genus-specific PCR primers and optimal
amplification conditions (Table
3). Direct cell lysis was used
to generate the DNA template. The PCR amplification reaction
with either of the primer pairs was performed by using Ex-
Taq DNA polymerase and the compatible PCR reagents (Panvera, Madison,
Wis.) in the GeneAmp PCR system model 9700. The reaction mixture
(50 µl) consisted of 5 µl of DNA template (cell
lysate), 1
x Ex-
Taq buffer with MgCl
2, 200 µM of each of
the four deoxynucleoside triphosphates, 100 ng of both the forward
and reverse primers, and 1.25 U of ex-
Taq DNA polymerase. The
presence of PCR products was determined by electrophoresing
10 µl of the reaction product on a 1% Trevigel gel matrix
(Trevigen, Gaithersburg, Md.) with 1
x Tris-acetate-EDTA buffer
containing ethidium bromide (0.5 µg/ml) and using 5 µl
of a 100-bp DNA size marker (PGC Scientifics [Frederick, Md.]
and Invitrogen [Carlsbad, Calif.]). Each PCR product was further
quantitated and photographed by using the Kodak EDAS 290 gel
documentation system (Kodak, Rochester, N.Y.).

Amplicon identification by restriction analysis and DNA sequencing.
The mycobacterial origin of the PCR products was confirmed by
restriction analysis. A protocol was optimized based on the
unique
NarI restriction site in these amplicons as determined
by aligning the available
hsp gene sequences for this region.
A randomly selected PCR amplicon (corresponding to the isolate
M-JY3) was also sequenced at the University of Cincinnati's
DNA core facility for confirmation. When analyzed with a BLAST
search against available gene database, the sequence showed
homology with
hsp gene sequences for mycobacteria. The sequence
showed closest homology (99%) with the
M. chelonae hsp sequence.
Of the five lysis reagents tested with a six-step heating regime (Tables 1 and 2), only reagent 4 (containing 2% SDS and 5% Triton X-100) and reagent 5 (2% SDS and 10% Triton X-100) yielded an effective cell lysis result as a prestep to PCR amplification (Fig. 1A). However, for some mycobacterial isolates such as M-JY4, lysis reagent 4 was not as effective as lysis reagent 5 (data not shown). The results showed that the proportional ratio of the two chemicals (SDS and Triton X-100) is important for achieving optimal cell lysis without interfering with the subsequent amplification reaction step. Hence, reagent 5 was selected as the optimum lysis reagent and was used for subsequent thermal regime optimizations. The six-step thermal regime was further modified and shortened by examining four other heating-cooling regimes (Fig. 1B). The five regimes tested gave nearly comparable cell lysis results for all reference strains and culture isolates when used with the optimal lysis reagent 5. Hence, the shortest thermal regime (V) involving heating at 98°C for 5 min followed by cooling at 4°C for 1 min was selected for the optimized protocol. This shows that the heating regime is not as critical as the chemical composition of the lysis reagent in achieving the desired cell lysis. Due to the relatively resistant cell walls of mycobacteria, various combinations of chemicals (such as SDS and Triton X-100), mechanical devices, heat, and solvents are often applied for the conventional extraction and purification of DNA from mycobacteria (1, 2, 15). However, these protocols are cumbersome and often time-consuming, and they fail to yield PCR-quality DNA; they also increase the chances of contamination or exposure during analysis. Our developed lysis protocol involves direct single-tube cell lysis in the PCR tube using a one-step heating cycle and has the potential for high-throughput applications as well as offering a safer alternative to conventional protocols. Single-tube cell lysis also makes the protocol ideal for use in quantitative PCR applications. The direct cell lysis procedure was also found to be equally effective against other bacteria, including both gram-negative and gram-positive bacteria (data not shown).
A 439-bp region of the
hsp gene has been used as a PCR target
for the identification and species differentiation in mycobacteria
by restriction enzyme analysis or nucleotide sequencing (
16,
18,
19,
21). In the preceding amplifications using this existing
hsp-based PCR method, one of the four reference strains and
two of the eight isolates yielded weak amplification signals
(Fig.
2A [I and II]). Quantification of the amplified PCR products
using the Kodak gel documentation system showed a range of DNA
concentrations (Fig.
2A [I and II]). Amplicon signal variability
among the reference strains (Fig.
1 and
2A) was traced to nucleotide
sequence variation in the primer binding regions based on multiple
alignment of their
hsp sequences using MegAlign 5.0 software
(DNASTAR, Inc., Madison, Wis.). Hence, in order to achieve unambiguous
PCR amplification for all NTM species, including the three strains
showing weak amplification, a new genus-specific primer pair
based on the sequence alignment of the available
hsp gene sequences
was designed. We selected modified PCR amplification conditions
compatible with the melting point values for the new primers
as determined by using Gene Runner software. When the optimized
lysis protocol was used, the modified protocol yielded a 228-bp
PCR product of comparable intensity and concentration for all
tested isolates and strains (Fig.
2B). All control strains of
various nonmycobacterial genera were negative, thus confirming
the genus-specific nature of the developed protocol. Moreover,
the modified PCR conditions optimized for the new primers resulted
in a relatively rapid amplification compared to that of the
existing method (Table
3).
The
NarI digestion of the amplicons, performed using recommended
digestion conditions (New England Biolabs, Beverly, Mass.),
yielded two fragments (192 and 36 bp) for the reference strains
and the eight isolates of mycobacteria (Fig.
3). The developed
genus-specific protocol for restriction pattern analysis of
the amplicons enabled rapid confirmation of the mycobacterial
identity of the environmental isolates.
In conclusion, the developed direct cell lysis-based PCR protocol
requires less than 2 h for identification of a putative mycobacterial
isolate, involving a 6-min lysis step followed by a 50-min amplification
and a 30- to 60-min gel analysis. The single-tube protocol is
potentially adaptable as a diagnostic tool in routine analytical
and clinical laboratories for rapid or high-throughput screening
with minimized risks of contamination or exposure. Confirmation
of the mycobacterial origin of the PCR product may require an
additional hour for restriction analysis. The detection time
(2.5 to 3.0 h) could be further shortened in situations in which
the real-time format for PCR is available, as the use of such
a format would allow early detection of the amplicon as well
as confirmation of the mycobacterial origin of the amplicon
based on melting-curve analysis.

Nucleotide sequence accession number.
The sequence described herein has been submitted to GenBank
(accession number
AY322157).

ACKNOWLEDGMENTS
The study was supported by a Centers for Disease Control and
Prevention National Institute of Occupational Safety and Health
grant (number 1R01OH007364-01A1 to J.S.Y.).
We thank Milacron management for providing the used MWF samples for isolation of mycobacteria.

FOOTNOTES
* Corresponding author. Mailing address: Molecular Toxicology Division, Department of Environmental Health, University of Cincinnati Medical Center, Kettering Laboratory, 3223 Eden Ave., Room 138, Cincinnati, OH 45267-0056. Phone: (513) 558-4806. Fax: (513) 558-4397. E-mail:
Jagjit.Yadav{at}uc.edu.


REFERENCES
1 - Armand, M. O., M. Mestdagh, and F. Porteals. 2001. DNA isolation from chloroform/methanol-treated mycobacterial cells without lysozyme and proteinase K. BioTechniques 30:272-274.[Medline]
2 - Bollet, C., M. J. Gevaudan, X. de Lamballerie, C. Zandotti, and P. D. Micco. 1991. A simple method for the isolation of chromosomal DNA from gram positive or acid-fast bacteria. Nucleic Acids Res. 19:1955.[Free Full Text]
3 - Covert, T. C., M. R. Rodgers, A. L. Reyes, and G. N. Stelma, Jr. 1999. Occurrence of nontuberculous mycobacteria in environmental samples. Appl. Environ. Microbiol. 65:2492-2496.[Abstract/Free Full Text]
4 - Dailloux, M., C. Laurain, M. Weber, and P. Hartemann. 1999. Water and nontuberculosis mycobacteria. Water Res. 33:2219-2228.[CrossRef]
5 - De Baere, T., R. de Mendonca, G. Claeys, G. Verschraegen, W. Mijs, R. Verhelst, S. Rottiers, L. Van Simaey, C. De Ganck, and M. Vaneechoutte. 2002. Evaluation of amplified rDNA restriction analysis (ARDRA) for the identification of cultured mycobacteria in a diagnostic laboratory. BMC Microbiol. 2:4-15.[CrossRef][Medline]
6 - Falkinham, J. O., III. 2002. Nontuberculous mycobacteria in the environment. Clin. Chest Med. 23:529-551.[CrossRef][Medline]
7 - Fraser, V., and R. J. Wallace, Jr. 1996. Nontuberculous mycobacteria, p. 1224-1338. In C. Glen. Mayhall (ed.), Hospital epidemiology and infection controls. Williams & Wilkins, Baltimore, Md.
8 - Freeman, A., J. Lockey, P. Hawley, P. Biddinger, and D. Trout. 1998. Hypersensitivity pneumonitis in a machinist. Am. J. Ind. Med. 34:387-392.[CrossRef][Medline]
9 - Kirschner, P., B. Springer, U. Vogel, A. Meier, A. Wrede, M. Kiekenbeck, F. C. Bange, and E. C. Bottger. 1993. Genotypic identification of mycobacteria by nucleic acid sequence determination: report of a 2-year experience in a clinical laboratory. J. Clin. Microbiol. 31:2882-2889.[Abstract/Free Full Text]
10 - Lummus, Z. L., J. E. Lockey, and I. L. Bernstein. 1998. Microbial flora of metalworking fluids associated with occupational respiratory disorders. J. Allergy Clin. Immunol. 1:166.
11 - Miyazaki, Y., H. Koga, S. Kohno, and M. Kaku. 1993. Predictive value of PCR applied to clinical samples for Mycobacterium tuberculosis detection. J. Clin. Microbiol. 31:2228-2232.[Abstract/Free Full Text]
12 - Muilenberg, M. L., H. A. Berge, and T. Sweet. 1993. Hypersensitivity pneumonitis and exposure to acid-fast bacilli in coolant aerosols. J. Allergy Clin. Immunol. 91:311.
13 - Reischl, U., M. Pulz, W. Ehret, and H. Wolf. 1994. PCR-based detection of Mycobacterium in sputum samples using a simple and reliable DNA extraction protocol. BioTechniques 17:844-845.[Medline]
14 - Shelton, G. B., W. D. Flanders, and K. G. Morris. 1999. Mycobacterium sp. as a possible cause of hypersensitivity pneumonitis in machine workers. Emerg. Infect. Dis. 5:270-273.[Medline]
15 - Talaat, A. M., R. Reimschuessel, and M. Trucksis. 1997. Identification of mycobacteria infecting fish to the species level using polymerase chain reaction and restriction enzyme analysis. Vet. Microbiol. 58:229-237.[CrossRef][Medline]
16 - Telenti, A., F. Marchesi, M. Balz, F. Bally, E. C. Bottger, and T. Bodmer. 1993. Rapid identification of mycobacteria to the species level by polymerase chain reaction and restriction enzyme analysis. J. Clin. Microbiol. 31:175-178.[Abstract/Free Full Text]
17 - Wallace, R. J., Jr., V. A. Silcox, M. Tsukamura, B. A. Brown, J. O. Kilburn, W. R. Butler, and G. Onyi. 1993. Clinical significance, biochemical features, and susceptibility patterns of sporadic isolates of the Mycobacterium chelonae-like organism. J. Clin. Microbiol. 31:3231-3239.[Abstract/Free Full Text]
18 - Wallace, R. J., Jr., Y. Zhang, R. W. Wilson, L. Mann, and H. Rossmoore. 2002. Presence of a single genotype of the newly described species Mycobacterium immunogenum in industrial metalworking fluids associated with hypersensitivity pneumonitis. Appl. Environ. Microbiol. 68:5580-5584.[Abstract/Free Full Text]
19 - Wilson, R. W., V. A. Steingrube, E. C. Bottger, B. Springer, B. A. Brown-Elliott, V. Vincent, K. C. Jost, Jr., Y. Zhang, M. J. Garcia, S. H. Chiu, G. O. Onyi, H. Rossmoore, D. R. Nash, and R. J. Wallace, Jr. 2001. Mycobacterium immunogenum sp. nov., a novel species related to Mycobacterium abscessus and associated with clinical disease, pseudo-outbreaks and contaminated metalworking fluids: an international cooperative study on mycobacterial taxonomy. Int. J. Syst. Evol. Microbiol. 51:1751-1764.[Abstract]
20 - Yadav, J. S., I. U. H. Khan, F. Fakhari, and M. B. Soellner. 2003. DNA-based methodologies for rapid detection, quantification, and species- or strain-level identification of respiratory pathogens (Mycobacteria and Pseudomonads) in metalworking fluids. Appl. Occup. Environ. Hyg. 18:966-975.[Medline]
21 - Yakrus, M. A., S. M. Hernandez, M. M. Floyd, D. Sikes, W. R. Butler, and B. Metchock. 2001. Comparison of methods for identification of Mycobacterium abscessus and M. chelonae isolates. J. Clin. Microbiol. 39:4103-4110.[Abstract/Free Full Text]
22 - Yoder, S., C. Argueta, A. Holtzman, T. Aronson, O. G. Berlin, P. Tomasek, N. Glover, S. Froman, and G. Stelma, Jr. 1999. PCR comparison of Mycobacterium avium isolates obtained from patients and foods. Appl. Environ. Microbiol. 65:2650-2653.[Abstract/Free Full Text]
Journal of Clinical Microbiology, January 2004, p. 453-457, Vol. 42, No. 1
0095-1137/04/$08.00+0 DOI: 10.1128/JCM.42.1.453-457.2004
Copyright © 2004, American Society for Microbiology. All Rights Reserved.
This article has been cited by other articles:
-
Kaser, M., Ruf, M.-T., Hauser, J., Marsollier, L., Pluschke, G.
(2009). Optimized Method for Preparation of DNA from Pathogenic and Environmental Mycobacteria. Appl. Environ. Microbiol.
75: 414-418
[Abstract]
[Full Text]
-
Agnew, D. W., Corbeil, L. B., Munson, L., Byrne, B. A., BonDurant, R. H.
(2008). A Pregnant Mouse Model for Bovine Tritrichomonas foetus Infection. Vet Pathol
45: 849-864
[Abstract]
[Full Text]
-
Elbir, H., Abdel-Muhsin, A.-M., Babiker, A.
(2008). A One-Step DNA PCR-based Method for the Detection of Mycobacterium tuberculosis Complex Grown on Lowenstein-Jensen Media. Am J Trop Med Hyg
78: 316-317
[Abstract]
[Full Text]
-
Richter, E., Rusch-Gerdes, S., Hillemann, D.
(2006). Evaluation of the GenoType Mycobacterium Assay for Identification of Mycobacterial Species from Cultures.. J. Clin. Microbiol.
44: 1769-1775
[Abstract]
[Full Text]
-
Khan, I. U. H., Selvaraju, S. B., Yadav, J. S.
(2005). Method for Rapid Identification and Differentiation of the Species of the Mycobacterium chelonae Complex Based on 16S-23S rRNA Gene Internal Transcribed Spacer PCR-Restriction Analysis. J. Clin. Microbiol.
43: 4466-4472
[Abstract]
[Full Text]
-
Aldous, W. K., Pounder, J. I., Cloud, J. L., Woods, G. L.
(2005). Comparison of Six Methods of Extracting Mycobacterium tuberculosis DNA from Processed Sputum for Testing by Quantitative Real-Time PCR. J. Clin. Microbiol.
43: 2471-2473
[Abstract]
[Full Text]